Reyds.Heat pumps · Boilers · Steam

Kwikot Industrial Water Heater · KS100

Kwikot Industrial Water Heater Repairs

Kwikot Industrial Water Heater Repairs across Gauteng. Breakdown repair of Kwikot industrial storage water heaters from 500 L to 3 000 L. Work covers the full Kwikot Industrial Water Heater range from the 500 L KS100 through to 3 000 L vessels, in vertical or horizontal configuration and in mild or stainless steel.

Repairs on Kwikot industrial water heaters normally begin with an electrical and thermostat check, then move to element resistance and insulation testing, panel contactor condition and finally the vessel itself. Most no-hot-water calls are element, thermostat or contactor failures rather than vessel faults.

Vessels are lined with Carboguard 545 or glass-flake epoxy, heated by flanged Incalloy elements and controlled from 6 kW–84 kW pre-wired panels, so any repair has to consider the water side, the element side and the panel together.

Recovery rate and storage volume have to be considered together; adding heating capacity to undersized storage rarely fixes a peak-hour shortfall. Sites with long, poorly insulated pipework lose more heat in distribution than most owners expect, which reads as a capacity problem at the outlet.

Range
500 L – 3 000 L
Turnaround
Single-element and thermostat repairs are normally completed in one visit; panel rebuilds may need a second.
Call
069 268 0988

Included

Scope of work

  • Element resistance and insulation testing
  • Control and over-temperature thermostat replacement
  • Contactor, overload and panel wiring repairs
  • Safety valve and drain valve replacement
  • Leak tracing on flanged connections
  • Post-repair recovery and temperature verification

What we work on

Equipment specification

Flagship modelKwikot KS100 — 500 L industrial water heater
Capacity range500 L, 750 L, 1 000 L, 1 500 L, 2 000 L, 2 500 L, 3 000 L
ConfigurationVertical or horizontal, floor-standing installation
Vessel materialMild steel or stainless steel
Internal protectionCarboguard 545 or glass-flake epoxy lining
ElementsIncalloy immersion elements, flanged
RecoveryApproximately 6 hours from cold to 60 °C at rated loading
Insulation50 mm IW24 fibreglass
Cladding0.6 mm galvanised or stainless steel
Safety devicesOver-pressure and over-temperature safety valves
ControlsControl thermostat plus independent over-temperature thermostat
Working pressureUp to 400 kPa standard, 600 kPa option
Electrical loading6 kW – 84 kW pre-wired control panels, custom loading to order
Panel optionsAmmeter, voltmeter, time switch, bypass switch, stepped control, low-water cut-out
ConnectionsFlanged inlet, outlet, element and drain connections

Coverage

Areas

FAQs

Frequently asked questions

Do you work on the Kwikot KS100 500 L industrial water heater?

Yes. The KS100 500 L vessel is the most common unit we attend, and the same work applies to the 750 L, 1 000 L, 1 500 L, 2 000 L, 2 500 L and 3 000 L models in the range.

What is included in kwikot industrial water heater repairs?

Element resistance and insulation testing, Control and over-temperature thermostat replacement, Contactor, overload and panel wiring repairs, Safety valve and drain valve replacement — with anything additional quoted before it is carried out.

How long does it take?

Single-element and thermostat repairs are normally completed in one visit; panel rebuilds may need a second.

How long should the vessel take to recover?

Nominal recovery is about six hours from cold to 60 °C at rated electrical loading. If measured recovery is materially slower, the usual causes are scaled elements, a failed element on one phase, or a stepped control panel not bringing all stages in. Where a site runs on borehole water, hardness and iron content shorten service intervals considerably and are worth testing before setting a maintenance plan.

Where do you carry out this work?

Across Johannesburg, Ekurhuleni, West Rand, Midrand, Centurion and Pretoria. Call 069 268 0988 or email info@reyds.co.za.

Can the plant be upgraded rather than replaced?

Often, yes. Electrical loading can be increased inside panel and cabling limits, storage can be banked with a second vessel, and a heat pump can be added ahead of the cylinder to carry base load with the elements as backup.

Kwikot Industrial Water Heater Repairs

Attendance across Johannesburg, Ekurhuleni, West Rand, Midrand, Centurion and Pretoria. Email info@reyds.co.za or call 069 268 0988.